| 引用本文: | 谢光军,胡茑庆,秦国军,等.基于转子固有频率的涡轮泵故障检测方法.[J].国防科技大学学报,2006,28(3):110-115 ,132.[点击复制] |
| XIE Guangjun,HU Niaoqing,Qin Guojun,et al.Research on Turbopump Fault Detection Based on Rotor Intrinsic Frequency[J].Journal of National University of Defense Technology,2006,28(3):110-115 ,132[点击复制] |
|
| |
|
|
| 本文已被：浏览 7177次 下载 6145次 |
| 基于转子固有频率的涡轮泵故障检测方法 |
| 谢光军, 胡茑庆, 秦国军, 胡海峰, 胡雷 |
|
(国防科技大学 机电工程与自动化学院，湖南 长沙 410073)
|
| 摘要: |
| 为了有效地检测液体火箭发动机涡轮泵的故障，分析了某型液体火箭发动机的28次历史试车数据，得到了涡轮泵转子的一阶、二阶和三阶临界转速以及轴向固有频率的数值，研究了这4个转子固有频率幅值的稳定性及对涡轮泵故障的敏感性，得出了它们具有较强的稳定性和故障敏感性的结论。在此基础上，提出并验证了基于转子固有频率的涡轮泵故障检测方法。结果表明，基于转子的一阶、二阶和三阶临界转速以及轴向固有频率幅值能有效地检测涡轮泵的故障。 |
| 关键词: 液体火箭发动机 涡轮泵 故障检测 转子固有频率 |
| DOI： |
| 投稿日期：2006-03-01 |
| 基金项目:国家863高技术研究发展计划资助项目(2002AA722070)；国家自然科学基金资助项目(50375153) |
|
| Research on Turbopump Fault Detection Based on Rotor Intrinsic Frequency |
| XIE Guangjun, HU Niaoqing, Qin Guojun, HU Haifeng, HU Lei |
|
(College of Mechatronics Engineering and Automation, National Univ. of Defense Technology, Changsha 410073, China)
|
| Abstract: |
| To detect faults of a liquid rocket engine (LRE) turbopump effectively, a turbopump fault detection approach based on rotor intrinsic frequency is presented in this paper. First of all, 28 LRE historical test data were analyzed, from which the values of the first, second and third order critical frequency and the axial intrinsic frequency were achieved. After that, the stability and turbopump fault sensitivity of this four rotor intrinsic frequencies were researched, from which we found that their intrinsic frequency amplitudes had high stability and fault sensitivity. Finally, the turbopump fault detection approach was validated by LRE historical test data. The results show that the turbopump faults can be detected effectively by using the amplitudes of rotor first, second and third order critical frequency as well as axial intrinsic frequency. |
| Keywords: liquid rocket engine turbopump fault detection rotor intrinsic frequency |
|
|
|
|
|
